Wacker Neuson GP 2500A Manual del operador Pagina 1

GeneratorGP 2500AOPERATOR’S MANUAL0163727en 00505090163727EN

Safety Information GP 2500A101.3 Operator Safety while using Internal Combustion EnginesInternal combustion engines present special hazards during ope

GP 2500A Safety Information111.4 Service SafetyPoorly maintained equipment can become a safety hazard! In orderfor the equipment to operate safely an

Safety Information GP 2500A121.5 Label Locations GND8889711223456

GP 2500A Safety Information131.6 Safety and Operating LabelsWacker Neuson machines use international pictorial labels whereneeded. These labels are de

Safety Information GP 2500A14WARNING! To reduce the risk of electrical shock and arc flash, read the Operator’s Manual. Improper connection of the ge

GP 2500A Safety Information15Open the fuel flow valve.Close the choke.Turn the engine switch to the ON position.Pull the rewind starter.Open the choke

Safety Information GP 2500A16This equipment does not meet California EVP emission regulations for small off-road engines.A nameplate listing the model

GP 2500A Operation172. Operation2.1 Determining Power RequirementsThis generator is designed to operate single-phase, 60 Hz appliancesrunning at 120 V

Operation GP 2500A182.2 InstallationPlace the generator in an area where it will not be exposed to rain,snow, or direct sunlight. Make sure it is posi

GP 2500A Operation192.3 Generator DeratingAll generators are subject to derating for altitude and temperature.Internal combustion engines, unless modi

DANGERCARBON MONOXIDEUsing a generator indoors CAN KILL YOU IN MINUTES.Generator exhaust contains carbon

Operation GP 2500A202.4 Grounding the GeneratorA ground connection (a) is located on the generator frame. For properoperating safety, this ground term

GP 2500A Operation212.6 Use of Extension CordsWhen a long extension cord is used to connect an appliance or tool tothe generator, a voltage loss occur

Operation GP 2500A222.7 Control PanelRef. Description Ref. Descriptiona GFI duplex receptacle—120V d GFI test buttonb Circuit breaker—20 Amp. e GFI re

GP 2500A Operation232.8 Ground Fault Interrupt (GFI)The 120V, 20 Amp receptacle (a) is equipped with a ground fault circuitinterrupt (GFI). The GFI sh

Operation GP 2500A242.10 Before Starting2.10.1 Read and understand the safety and operating labels and instructionsat the beginning of this manual.2.1

GP 2500A Operation252.11 To Start2.11.1 Ensure that the generator is properly installed in an outdoor location.See Sections Installation and Operator

Maintenance GP 2500A263. Maintenance3.1 Engine MaintenanceThe chart below lists basic machine and engine maintenance. Refer toyour engine operator’s m

GP 2500A Maintenance273.3 Engine Oil3.3.1 Drain the oil while the engine is still warm.3.3.2 Remove the oil filler plug (a) and the drain plug (b) to

Maintenance GP 2500A283.4 Servicing Air CleanerService the air cleaner frequently to prevent carburetor malfunction. NOTICE: NEVER run the engine with

GP 2500A Maintenance293.5 Spark PlugClean or replace the spark plug as needed to ensure proper operation.Refer to your engine operator’s manual. T

wc_tx000001gb.fm 3CALIFORNIAProposition 65 Warning: Engine exhaust, some of its constituents, and certain vehiclecomponents, contain or emit chemical

Maintenance GP 2500A303.6 Cleaning the Sediment Cup3.6.1 Turn the fuel valve off. 3.6.2 Remove the sediment cup (a) and the O-ring (b). 3.6.3 Wash bot

GP 2500A Maintenance313.7 Carburetor Adjustment3.7.1 Start the engine and allow it to warm up to operating temperature.3.7.2 Set the pilot screw (a) t

Maintenance GP 2500A323.8 Adjusting Engine SpeedGenerators require a fixed engine speed to maintain the correctvoltage. Engine speed is controlled by

GP 2500A Maintenance333.10 Transport Let the engine cool before transporting the generator or storing itindoors, to avoid burns or fire hazards.When t

Maintenance GP 2500A343.12 Wire Colors3.13 Wiring Schematic Wire ColorsB Black R Red Y Yellow Or OrangeG Green T Tan Br Brown Pr PurpleL Blue V Vio

GP 2500A Maintenance35811910

Technical Data GP 2500A364. Technical Data4.1 GeneratorItem No. GP 2500A0620128GeneratorMaximum OutputW2500Continuous OutputW2250Type Single voltage,

GP 2500A Technical Data374.2 EngineEngine Power RatingNet power rating per SAE J1349. Actual power output may vary due toconditions of specific use.It

Wacker Neuson SE · Preußenstraße 41 · D-80809 München · Tel.: +49-(0)89-3 54 02-0 · Fax: +49 - (0)89-3 54 0

wc_tx000001gb.fm 4

GP 2500A Table of Contents5Foreword 31 Safety Information 71.1 Laws Pertaining to Spark Arresters ...

Table of Contents GP 2500Awc_bo0163727en_005TOC.fm 63 Maintenance 263.1 Engine Maintenance ...

GP 2500A Safety Information71. Safety InformationThis manual contains DANGER, WARNING, CAUTION, NOTICE, andNOTE callouts which must be followed to red

Safety Information GP 2500A81.2 Operating SafetyUsing a generator indoors CAN KILL YOU IN MINUTES. Generatorexhaust contains carbon monoxide. This is

GP 2500A Safety Information91.2.8 NEVER allow untrained personnel to operate or service the generator.The generator set should be set up by a certifie