Wacker Neuson PDI 3 Manual del operador

www.wackergroup.comPumpPDT 2PDI 2PDT 3PDI 3OPERATOR’S MANUAL0160360en 00101070160360EN

Emission Control System Informationwc_tx000239gb.fm 8PARTS COVERED Listed below are the parts covered by the Emission ComponentsDefect Warranty. Some

Emission Control System Informationwc_tx000239gb.fm 9OBTAINING WARRANTY SERVICETo obtain warranty service, take your engine to the nearest authorizedW

Emission Control System Informationwc_tx000239gb.fm 10THINGS YOU SHOULD KNOW ABOUT THE EMISSION CONTROLSYSTEM WARRANTY:MAINTENANCE AND REPAIRS You are

Emission Control System Informationwc_tx000239gb.fm 11Your emission control system may include parts such as the carburetoror fuel-injection system, f

Emission Control System Informationwc_tx000239gb.fm 12GENERAL EMISSIONS WARRANTY COVERAGE- California Only -Wacker warrants to the ultimate purchaser

Emission Control System Informationwc_tx000239gb.fm 137) Wacker is liable for damages to other engine componentsproximately caused by a failure under

Emission Control System Informationwc_tx000239gb.fm 14C. Warranted Parts:The repair or replacement of any warranted part otherwise eligible forwarrant

PD 2/3 Safety Informationwc_si000144gb.fm 153. Safety InformationThis manual contains DANGER, WARNING, CAUTION, and NOTEcallouts which must be followe

Safety Information PD 2/3wc_si000144gb.fm 163.2 Operating SafetyInternal combustion engines present special hazards during operationand fueling. Read

PD 2/3 Safety Informationwc_si000144gb.fm 173.3 Operator Safety while using Internal Combustion EnginesPoorly maintained equipment can become a safety

Safety Information PD 2/3wc_si000144gb.fm 183.5 Label LocationsDO NOT OPERATE WITHOUT SAFETY GUARDS. READ AND UNDERSTAND INSTRUCTION BOOK.NICHT OHNE

PD 2/3 Safety Informationwc_si000144gb.fm 193.6 Safety LabelsWacker machines use international pictorial labels where needed.These labels are describe

Safety Information PD 2/3wc_si000144gb.fm 20CAUTION! Lifting pointGuaranteed sound power level in dB(A)Label Meaning

PD 2/3 Technical Datawc_td000144gb.fm 214. Technical Data4.1 EngineItem Number:PDI/PDT 20009489, 0009494PDI/PDT 30009491, 0009492, 0009495EngineEngine

Technical Data PD 2/3wc_td000144gb.fm 224.2 Pump4.3 Sound MeasurementsThe required sound specification, Paragraph 1.7.4.f of 89/392/EECMachinery Direc

PD 2/3 Operationwc_tx000405gb.fm 235. Operation5.1 ApplicationThis pump is intended for removing clean water or water containing alarge amount of debr

Operation PD 2/3wc_tx000405gb.fm 245.3 Priming PumpSee Graphic: wc_gr001064Diaphragm pumps are self priming and seldom need to have wateradded to the

PD 2/3 Operationwc_tx000405gb.fm 255.5 To StartSee Graphic: wc_gr0006555.5.1 Open fuel valve by moving lever down (a1).Note: If engine is cold, move

Operation PD 2/3wc_tx000405gb.fm 265.7 OperationRun engine at full speed while operating pump.Pump should begin pumping water within a minute dependin

PD 2/3 Operationwc_tx000405gb.fm 275.9 Hoses and ClampsSee Graphic: wc_gr001065Suction HoseSuction hoses (a) must be rigid enough not to collapse when

PD 2/3 Table of Contentswc_bo0160360en_001TOC.fm 11. Foreword 32. Emission Control System Information 43. Safety Information 153.1 Laws Pertaining to

Maintenance PD 2/3wc_tx000406gb.fm 286. Maintenance6.1 Periodic Maintenance ScheduleThe chart below lists basic machine and engine maintenance. Refer

PD 2/3 Maintenancewc_tx000406gb.fm 296.2 Changing Engine OilSee Graphic: wc_gr0000876.2.1 Drain oil while engine is still warm.Note: In the interests

Maintenance PD 2/3wc_tx000406gb.fm 306.4 Servicing Air CleanerSee Graphic: wc_gr000656NEVER use gasoline or other types of low flash point solvents fo

PD 2/3 Maintenancewc_tx000406gb.fm 316.5 Spark PlugSee Graphic: wc_gr000028Clean or replace spark plug as needed to ensure proper operation. The muff

Maintenance PD 2/3wc_tx000406gb.fm 326.6 Gear CaseSee Graphic: wc_gr001066Check the oil level in the gear case once a week or every 25 hours ofoperati

PD 2/3 Maintenancewc_tx000406gb.fm 336.7 Connecting Rod BearingSee Graphic: wc_gr001067Grease connecting rod bearing once a week or every 25 hours ofo

Maintenance PD 2/3wc_tx000406gb.fm 346.9 StorageIf pump is being stored for more than 30 days: NEVER open priming plug, discharge plug, or cover when

PD 2/3 Maintenancewc_tx000406gb.fm 356.10 TroubleshootingProblem / Symptom Reason / RemedyEngine does not start. • Engine problem. See engine manufact

Maintenance PD 2/3wc_tx000406gb.fm 36Notes:

Table of Contents PD 2/3wc_bo0160360en_001TOC.fm 26. Maintenance 286.1 Periodic Maintenance Schedule ...

wc_tx000001gb.fm 3CALIFORNIAProposition 65 Warning: Engine exhaust, some of its constituents, and certain vehiclecomponents, contain or emit chemical

2005-CE-PD2_3-Q.fmWilliam Lahner Dan DomanskiVice President of Engineering

Wacker Construction Equipment AG · Preußenstraße 41 · D-80809 München · Tel.: +49-(0)89-3 54 02 - 0 · Fax:

Emission Control System Informationwc_tx000239gb.fm 42. Emission Control System InformationSource of EmissionsThe combustion process produces carbon m

Emission Control System Informationwc_tx000239gb.fm 5Replacement PartsThe emission control systems on your Wacker engine were designed,built, and cert

Emission Control System Informationwc_tx000239gb.fm 6METHANOL - (methyl or wood alcohol) 5% by volume. You may usegasoline containing up to 5% methano

Emission Control System Informationwc_tx000239gb.fm 7EMISSIONS COMPONENT DEFECT WARRANTY COVERAGEThis emission warranty is applicable in all States, e